煤系煅烧高岭土吸油值的影响因素
DOI:
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

基金项目:

国家自然科学基金(41102025);教育部纳米矿物材料及应用工程研究中心开放基金(CUGNGM20132)


Factors influencing oil adsorption of calcined coal-series kaolin
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    涂布造纸填料用煅烧高岭土要求有较高的吸油值.本文针对市场上高吸油值煅烧高岭土资源短缺的现状,研究煅烧高岭土吸油值的影响因素,寻求提高煅烧高岭土吸油值的方法.实验以唐山煤系高岭土为原料,在600~1 000℃范围内间隔50℃取点,分别煅烧3 h.采用扫描电子显微镜(SEM)、X射线衍射仪(XRD)观察煅烧高岭土的形貌并鉴定其物相.计算煅烧高岭土的烧失量,并检测其pH值、比表面积、Zeta电位等参数,分析它们对煅烧高岭土的吸油值的影响.结果表明: 750℃煅烧的高岭土吸油值最高,可达76.3 g/100 g;煅烧高岭土的Zeta电位、pH值、比表面积等对其吸油值的影响均较为显著,其中比表面积对吸油值的影响最大.

    Abstract:

    Calcined kaolin used in specific paper filler requires a higher oil absorption value. In view of the resource shortages of the calcined kaolin with high oil absorption value in the market, this study aims at investigating factors influencing the oil adsorption of the calcined coal-series kaolin and seeking for ways to improve the oil absorption value of calcined kaolin. Coal-series kaolin used as raw materials in this study was obtained from Tangshan area, which was calcined in the temperature range of 600~1 000 ℃, with the interval of 50℃. Scanning electron microscope (SEM) and X-ray diffraction (XRD) were used to conduct morphologic observation and phase identification of calcined kaolin respectively. Calculation of loss on ignition and detection of such parameters as pH value, specific surface area and Zeta potential were used to analyze their influences on oil adsorption value. The results show that the highest oil adsorption value of calcined kaolin is up to 76.3 g/100 g at the temperature of 750℃; and Zeta potential, pH value, specific surface area constitute the notable factors influencing oil adsorption value, with the influence of specific surface area on the oil absorption value of the calcined kaolin being the greatest.

    参考文献
    相似文献
    引证文献
引用本文

孙涛,周春宇,陈洁渝,雷新荣,严春杰,朱晓燕,2013,煤系煅烧高岭土吸油值的影响因素[J].岩石矿物学杂志,32(2):232~238. SUN Tao, ZHOU Chun-yu, CHEN Jie-yu, LEI Xin-rong, YAN Chun-jie, ZHU Xiao-yan,2013,Factors influencing oil adsorption of calcined coal-series kaolin[J]. Acta Petrologica et Mineralogica,32(2):232~238.

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2012-10-08
  • 最后修改日期:2012-11-21
  • 录用日期:
  • 在线发布日期:
  • 出版日期: